Print

2002 - 2005 Models

  7500
 15000
 		22500
 		30000
 		37500
 		45000
 		52500
 60000
67500
75000
82500
90000
97500
105000
112500
120000
Replace engine oil
 
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Replace oil filter
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Replace air filter



 



 



 
  
Replace auxiliary drive belt















Replace brake fluid                    
      
 
  
Replace cabin particle filter    
    
    
    
    
    
    
    
Replace fuel filter                           3
   
Replace spark plugs    
    
   2
  1
   
    
    
   1
Replace timing belt & tensioner        
        
        
    3    
Reset Service Reminder (SRL)  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Rotate tires, set tire pressures as required  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Install BG44K fuel additive (carbon cleaner) R
R
R
R
R
 R
R
R
R
R
R
R
R
R
R
R
Install BG MOA Oil Additive (engine oil additive)
R
 
 R
 
 R
 
 R
 
 R
 
 R
 
 R
 
 R
Adjust coolant overflow level, inspect coolant















Adjust power steering fluid level

 
  
  
  
  
  
  
  
  
  
  
  
  
  
Adjust tire pressures as needed  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Adjust washer fluid level  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Balance Tires 4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
Check automatic transmission fluid condition



 
  

 
  
  
  
  
  
  
  
Check battery for condition and charge
 
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Check for diagnostic codes; reset service reminder
 
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Clean power antenna mast (where applicable)
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Inspect all exterior lights
 
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Inspect bevel gear (AWD Only)
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Inspect brake fluid level
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Inspect drive belts; adjust as needed
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Inspect driveshaft joints/boots
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Inspect exhaust system
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Inspect front & rear brakes; adjust parking brake
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Inspect front & rear suspension; retorque as needed
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Inspect fuel lines
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Inspect PCV valve/hoses
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Inspect wiper blades
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
Lubricate door, hood,trunk hinges, weatherstrips
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  
  

(An oil & filter service is recommended 3,750 miles after each of these services due to extreme driving conditions in the Atlanta area.)
1: 60,000 mile interval for all models except 2004 and below s40's
2: 45,000 mile interval for s40 2002-2004.5 models only all others 60,000 mile intervals
3: 105,000 mile intervals for all models except VIN codes 59 & 61 which are done at 120,000 mile intervals
4: 4-wheel balancing is recommended every 7500 miles for best performance; see service advisor for additional cost of this service.
R: Services are included by North Point Volvo but are not part of Volvo Scheduled Maintenance
Grey Box =  Already included with service

Preventative maintenance is important!  Servicing your Volvo according to the manufacturer's recommendations not only assures smooth, efficient operation but also meets existing warranty requirements!  Please call your Service Consultant for an appointment today!